Product ID:HIGH PERFORMANCE GEAR OIL 75W90
MSDS Date:02/27/1996
FSC:9150
NIIN:00F056027
MSDS Number: CGWCT

VALVOLINE OIL CO (FORMERLY IN ASHLAND KENTUCKY)

3499 DABNEY DR
LEXINGTON, KY 40512-5000
US

Emergency Phone: 606-264-7000/800-274-5263

Info Phone: 606-264-7000/800-274-5263

Cage: 72527

VALVOLINE OIL CO

14000 LEXINGTON, KY 40512 US

Telephone: 606-357-7206 / 800-274-5263

Cage: 72527

OIL PETROLEUM DISTILLATES, SOLVENT-DEWAXED HEAVY PARAFFINIC

CAS: 64742-65-0

RTECS: PY8038500

Fraction By Weight: 65-75%

VISCOSITY IMPROVER

Fraction By Weight: 15-25%

LUBE OIL ADDITIVE

Fraction By Weight: 4.9-15%

MINERAL OIL, PETROLEUM DISTILLATES, SOLVENT-REFINED HEAVY

CAS: 64741-88-4

RTECS: PY8040500

Fraction By Weight: 1-11%

OSHA PEL 5 MG/CUM

ACGIH TLV: 5 MG/CUM

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN: MILD IRRITATION & BURNS.
INGESTION: LARGE AMOUNTS MAY BE HARMFUL. GI IRRITATION. INHALATION:
IRRITATION OF THE NOSE, THROAT & RESPIRATORY TRACT.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, DRYNESS, REDNESS, BURNS, CRACKING,
NAUSEA, VOMITING, DIARRHEA, ABDOMINAL PAIN.
Medical Cond Aggravated by Exposure:PRE-EXISTING LUNG & SKIN DISORDERS,
ASTHMA LIKE CONDITIONS.

First Aid:EYES: REMOVE TO FRESH AIR. FLUSH GENTLY W/WATER. SKIN: WASH
W/SOAP & WATER. INGESTION: DON'T INDUCE VOMITING. GIVE 1 GLASS OF
MILK/WATER. DON'T LEAVE VICTIM UNATTENDED. INHALATION: REMOVE TO
FRESH AIR . KEEP WARM & QUIET. GIVE CPR/OXYGEN IFNEEDED. OBTAIN
MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:COC
Flash Point:380F
Extinguishing Media:REGULAR FOAM, CO2, DRY CHEMICAL.
Fire Fighting Procedures:WEAR A SCBA W/A FULL FACEPIECE W/APPRORIATE
TURN-OUT GEAR & CHEMICAL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
DRUM, PRODUCT CAN IGNITE EXPLOSIVELY. DENSE SMOKE MAY BE GENERATED.
WATER/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT.

Spill Release Procedures:SMALL: ABSORB LIQUID ON VERMICULITE/FLOOR
ABSORBENT/OTHER MATERIAL. LARGE: PREVENT RUN-OFF TO
SEWERS/STREAMS/OTHER BODIES OF WATER. EVACUATE AREA UNTIL CLEANUP
IS COMPLETED. STOP AT SOURCE & DIKE TO P REVENT SPREADING/PUMP
LIQUID TO SALVAGETANK.(SUPP

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUES, ALL PRECAUTIONS MUST BE OBSERVED.

Respiratory Protection:IF OIL MISTS ARE GENERATED ABOVE RECOMMENDED
PEL/TLV, THEN A NIOSH/MSHA APPROVED RESPIRATOR IS ADVISED.
Ventilation:SUFFICIENT MECHANICAL(GENERAL/LOCAL EXHAUST)TO MAINTAIN
EXPOSURE BELOW PEL/TLV.
Protective Gloves:NITRILE RUBBER
Eye Protection:SAFETY GLASSES/CHEMICAL SPLASH GOGGLES
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS & LEGS.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
SPILLS CONT'D: REMAINING LIQUID MAY BE TAKEN UP ON SAND, CLAY, EARTH,
FLOOR ABSORBENT/OTHER ABSORBENT MATERIAL & SHOVELED INTO
CONTAINERS.

Boiling Pt:B.P. Text:>425F
Spec Gravity:0.890
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:DRY CLEAR & BRIGHT AMBER LIQUID

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Hazardous Decomposition Products:CO2 & CO, VARIOUS HYDROCARBONS.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.